Wastewater Treatment Ponds: Solar-Powered Circulators Provide Barrier to Noxious Odors at Shell Oil Martinez Refinery

Share Article

Solar-powered circulators provide reliable wastewater odor control to prevent health hazards, public outrage and air quality citations Â?- along with major savings.

In wastewater treatment, the prevention of odors escaping from storage ponds is so problematic it is a disaster-waiting-to-happen. Even an occasional lapse in maintaining an effective odor cap can have dire consequences including health hazards, public outrage, and even shutdowns.

Such scenarios are not limited to sludge storage ponds. Industrial storage basins holding manufacturing effluents, and even rainwater, contain odor-producing sulfurous compounds that can waft over communities unless capped effectively.

“We are very concerned about maintaining an odor cap,” says David Williams, Project Engineer at Shell Oil for the Martinez, California refinery. “Our wastewater treatment pond is about 1/4 mile from the residential community. We’ve got a delicate situation where even just a slight amount of odor could arouse complaints from the community.”

William’s concern about wastewater odor control led him to looking for a new aeration technology to replace two brush aerators that had been attributed to incidents that produced odor complaints from local residents.

The solution was the SolarBee, a solar-powered water “circulator” from Pump Systems (http://www.solarbee.com) that aerates ponds by circulating the top two feet of water at a rate of up to 10,000 gallons per minute. This circulation occurs with a gentle, “near laminar” long-distance flow pattern that provides an oxygenated odor cap across the entire surface 24 hours a day.

This solution provided impressive cost savings. “Because the wastewater treatment pond is at a remote location, we had been using rented diesel generators to power the brush aerators,” Williams explains. The total rental costs for testing that system was about $15,000 a month. The alternative of powering the site from the grid would have cost up to $150,000 due to the remote location and electrical classification. As an added bonus, SolarBees reduce energy costs by $10,000/year compared to hard-wired aerators.

Williams reports that since the installation of the circulator systems, the Martinez wastewater treatment pond “has had zero odor complaints due to inadequate aeration.”

Contact:

Joel Bleth

Pump Systems

866-437-8076

http://www.solarbee.com

###

Share article on social media or email:

View article via:

Pdf Print

Contact Author

Joel Bleth
Visit website