Independent Laboratory Reports Kaivac’s AutoVac Cleaning System Has ATP Reduction of More Than 99 Percent

Share Article

The TURI Surface Solutions Laboratory at the University of Massachusetts, in Lowell, has reported the results from a series of tests that compared the cleaning effectiveness of Kaivac’s new AutoVac Cleaning System. The report indicates the average reduction in ATP using the OmniFlex system matched—or exceeded—the effectiveness of an automatic scrubber.

Kaivac's AutoVac System

The report indicates that the average reduction in ATP using the OmniFlex system matched—or exceeded—the effectiveness of an automatic scrubber.

The TURI Surface Solutions Laboratory at the University of Massachusetts, in Lowell, has reported the results from a series of tests that compared the cleaning effectiveness of Kaivac’s new AutoVac Cleaning System with more conventional floor cleaning methods, such as using a microfiber mop and an autoscrubber.

The AutoVac, which is part of Kaivac’s OmniFlex™ Crossover Cleaning System, was recently certified by the National Floor Safety Institute (NFSI). It is also entered in the “equipment” category of this year’s ISSA Innovation Awards Program.

To perform the tests, TURI researchers first cleaned and then sterilized an eight-by-four-foot area of a finished vinyl composite tile (VCT) floor. Next, they used an ATP meter to verify that the floor was hygienically clean.

Then, the following test steps were taken:

  •     Researchers applied freshly squeezed seedless grape juice diluted with water to the floor and allowed it to dry before conducting baseline ATP readings.
  •     They cleaned one area of the floor with a microfiber mop and Kaivac’s KaiO™ multipurpose floor cleaning solution, diluted per manufacturer’s instructions.
  •     They cleaned another section of the floor using the same cleaning solution using an automatic scrubber.
  •     Finally, using the same cleaning solution, they made three passes with an OmniFlex AutoVac to clean a third section of the floor.

In each case, once the floor was dry, researchers collected ATP readings.

The results indicated that all three cleaning methods lowered ATP levels. However, the report indicated that the average reduction in ATP using the OmniFlex system matched—or exceeded—the effectiveness of an automatic scrubber.

Actual reduction in ATP with the AutoVac Cleaning System was almost 100 percent. (See Sidebar: High Points of the TURI Report)

“Our own testing indicated the [cleaning] effectiveness of the system would be very high,” says John Richter, Technical Director for Kaivac. “However, these results were very impressive, even exceeding what we anticipated.”

-end-

Click Here for the Complete Study

Sidebar: High Points of the TURI Report

  •     The overall results of the studies indicate the Kaivac AutoVac system performed “as well as or better than the automatic scrubber” as measured by the reduction in the amount of ATP and bacteria on the floor after cleaning.
  •     The mop was found “to be an ineffective way of removing bacteria from a hard surface.”
  •     Both the AutoVac system and the automatic scrubber “had significant reduction in ATP levels” of plus or minus 99 percent of the test floor area.
  •     The vacuum removal of bacteria using the AutoVac system “is instrumental in eliminating the bacteria from the floor and minimizing cross contamination.”

Visit Kaivac on Facebook at: [http://tiny.cc/sbkd5.

Share article on social media or email:

View article via:

Pdf Print

Contact Author

Robert Kravitz
Visit website